Unitec Wash Select II POS Installation Manual User Manual

Wash Select II  and Wash Select II  POS Installation Manual Unitec www.StartwithUnitec.com (443) 561-1200

WASH SELECT II Document Number: WS21001 4 Document Title: Wash Select II POS Installation Manual 1.2 Mechanical Planning 1.2.1 Position o

WASH SELECT II Document Number: WS21001 5 Figure 3. Wash Select II Base Placement 1.3 Miscellaneous Planning 1.3.1 Precautionary Consider

WASH SELECT II Document Number: WS21001 6 Document Title: Wash Select II POS Installation Manual  Installation & Operation Manuals

WASH SELECT II Document Number: WS21001 7 Document Title: Wash Select II POS Installation Manual 2 Tools Required for Installation 2.1

WASH SELECT II Document Number: WS21001 8 Document Title: Wash Select II POS Installation Manual

WASH SELECT II Document Number: WS21001 9 Document Title: Wash Select II POS Installation Manual 3 Mechanical Installation  Note: Unite

WASH SELECT II Document Number: WS21001 10 Figure 4. Wash Select II Installation Hint: Most installers may need to increase the protecti

WASH SELECT II Document Number: WS21001 11 Figure 5. Straight Base Figure 6. Angled Base 1. Mark the 4 holes that you intend to drill in

WASH SELECT II Document Number: WS21001 12 2. Remove the base from the marked location and proceed to drill the holes, using the hammer d

WASH SELECT II Document Number: WS21001 13 Document Title: Wash Select II POS Installation Manual 2. Set the unit onto the base, and ali

WASH SELECT II Document Number: WS21001 Document Title: Wash Select II POS Installation Manual WASH SELECT II INSTALLATION MANUAL This

WASH SELECT II Document Number: WS21001 14 Document Title: Wash Select II POS Installation Manual [THIS PAGE INTENTIONALLY LEFT BLANK]

WASH SELECT II Document Number: WS21001 15 4 Electrical Installation 4.1 Wiring the Modem (Option) The modem is optional. If any of th

WASH SELECT II Document Number: WS21001 16 1. Locate the other end of the phone modem wire. This may have its own conduit run, or it may

WASH SELECT II Document Number: WS21001 17 the router in the C-store and plugged into the J4 Ethernet connector located on the pre-install

WASH SELECT II Document Number: WS21001 18 Document Title: Wash Select II POS Installation Manual 2. Remove this connector from the sock

WASH SELECT II Document Number: WS21001 19 4.4.3 Wash-Fault Some car wash manufactures include another interface signal to a unit, the WAS

WASH SELECT II Document Number: WS21001 20 hopper handle, and pulling it out the front. The cable that connects it to the CPU board will n

WASH SELECT II Document Number: WS21001 21 Figure 12. Inside the AC Connector 2. Remove the line insulator and set it aside for the next

WASH SELECT II Document Number: WS21001 22 Figure 14. Line - Neutral - Ground Connections 5. When all of the wires have been attached, pu

WASH SELECT II Document Number: WS21001 23 Intercom cable2-wire connection: pin-1 = audio/call feed. Pin-2 = audio/call ground Figure

WASH SELECT II Document Number: WS21001 i Document Title: Wash Select II POS Installation Manual Table of Contents 1 Site Planning...

WASH SELECT II Document Number: WS21001 24 Document Title: Wash Select II POS Installation Manual 4.7.3 Connecting a 4-wire Intercom Syst

WASH SELECT II Document Number: WS21001 25 Document Title: Wash Select II POS Installation Manual Table 6. J 2 of Unitec Wash Card interf

WASH SELECT II Document Number: WS21001 26 Document Title: Wash Select II POS Installation Manual Number (Old Version) (New Version) 1

WASH SELECT II Document Number: WS21001 27 Document Title: Wash Select II POS Installation Manual 6 10-16VDC- Isolated eWash J5 Pin 5 R

WASH SELECT II Document Number: WS21001- L 28 5 Startup / Programming For the following sections, the Wash Select II unit must be powered

WASH SELECT II Document Number: WS21001 29 Document Title: Wash Select II POS Installation Manual by the (*)-key. All wash prices must be

WASH SELECT II Document Number: WS21001 30  No/Pulsed – Relays are turned on for a 2 second pulse when the arming signal is sent to the c

WASH SELECT II Document Number: WS21001 31 Document Title: Wash Select II POS Installation Manual 5.2.5 Wash Handshaking Wash handshaking

WASH SELECT II Document Number: WS21001 32 Document Title: Wash Select II POS Installation Manual is listed at $5.00. They proceed to inse

WASH SELECT II Document Number: WS21001 33 Document Title: Wash Select II POS Installation Manual the lights is blinking, you may have a f

WASH SELECT II Document Number: WS21001 ii Document Title: Wash Select II POS Installation Manual 4.7.1 Connecting a 2-wire Intercom Sys

WASH SELECT II Document Number: WS21001 34 Document Title: Wash Select II POS Installation Manual Begin with the master unit. 1. Enter th

WASH SELECT II Document Number: WS21001 35 Document Title: Wash Select II POS Installation Manual Multi-Coin Acceptors: If you have the

WASH SELECT II Document Number: WS21001 36 Document Title: Wash Select II POS Installation Manual 2. Verify that every wash purchased giv

WASH SELECT II Document Number: WS21001 37 Document Title: Wash Select II POS Installation Manual [THIS PAGE INTENTIONALLY LEFT BLANK]

WASH SELECT II Document Number: WS21001- L 38 Appendix A. Guide for Alternate Keypad Functions This diagram shows all of the alphanumeric k

WASH SELECT II Document Number: WS21001 39 Document Title: Wash Select II POS Installation Manual [THIS PAGE INTENTIONALLY LEFT BLANK]

WASH SELECT II Document Number: WS21001 40 Document Title: Wash Select II POS Installation Manual Appendix B. Recorded Speech Messages Rec

WASH SELECT II Document Number: WS21001 41 Document Title: Wash Select II POS Installation Manual 6) PACKAGE 4 PURCHASED (8.5 seconds) Y

WASH SELECT II Document Number: WS21001 42 Document Title: Wash Select II POS Installation Manual 19) NETWORK ERROR (4.25 seconds) Sorr

WASH SELECT II Document Number: WS21001 43 Document Title: Wash Select II POS Installation Manual [THIS PAGE INTENTIONALLY LEFT BLANK]

WASH SELECT II Document Number: WS21001 iii Document Title: Wash Select II POS Installation Manual Index of Figures Figure 1. Conduits

WASH SELECT II Document Number: WS21001- L 44 Document Name: Wash Select II POS Installation Manual 5.00 Appendix C. Paging Error Codes N

WASH SELECT II Document Number: WS21001 45 Document Title: Wash Select II POS Installation Manual Error Code # (Numeric) Text Name (Text/T

WASH SELECT II Document Number: WS21001 46 Document Title: Wash Select II POS Installation Manual Appendix D. Additional Steps for Canadi

WASH SELECT II Document Number: WS21001 47 Document Title: Wash Select II POS Installation Manual NOTE: You can do this only for the stand

WASH SELECT II Document Number: WS21001 48 Document Title: Wash Select II POS Installation Manual 3. If you are accepting quarters: 1. R

WASH SELECT II Document Number: WS21001 49 2. Press the button to the immediate left once 3. Drop the six sample tokens and note that the

WASH SELECT II Document Number: WS21001 50 Document Title: Wash Select II POS Installation Manual NOTE: The IDX coin-acceptor can be progr

WASH SELECT II Document Number: WS21001 51 Document Title: Wash Select II POS Installation Manual 8. If you are still having problems, ch

WASH SELECT II Document Number: WS21001 52 Document Title: Wash Select II POS Installation Manual 12. If you have any clues from the prin

WASH SELECT II Document Number: WS21001 53 Document Title: Wash Select II POS Installation Manual [THIS PAGE INTENTIONALLY LEFT BLANK]

WASH SELECT II Document Number: WS21001 iv Document Title: Wash Select II POS Installation Manual [THIS PAGE INTENTIONALLY LEFT BLANK]

WASH SELECT II Document Number: WS21001 54 Appendix E. Single Gate Installation (Without Gate Controller) The Barrier Gate option allows y

WASH SELECT II Document Number: WS21001 55 1. Electrical Planning In addition to the standard three conduits carrying wash signal wiring, c

WASH SELECT II Document Number: WS21001 56 Figure 21. Gate Position 3. Mechanical Installation You will be installing the gate directly i

WASH SELECT II Document Number: WS21001 57 With the dimensions as specified above, you will need to loop the wire 5 times around the loop.

WASH SELECT II Document Number: WS21001 58 6. Connect the gate reset loop leads to terminals 15 and 16 inside the gate. Refer to the follo

WASH SELECT II Document Number: WS21001 1 Document Title: Wash Select II POS Installation Manual 1 Site Planning The Wash Select II is a

WASH SELECT II Document Number: WS21001 2 not be run in the same conduit as the main power lines. Telephone, as well as intercom connectio

WASH SELECT II Document Number: WS21001 3 For Internet credit clearing, Kwik Trip, or WashPay integration, Ethernet cable will be needed.